Tie-down Vector Dynamics Foundation System for Wind Zones I Bedienungsanleitung PDF herunterladen (Seite 17)

Page 17 4/3/2013

9. Putawasherandnutononeofthe3/8”x3-3/4”wedgeanchors.Thenutshouldbescrewedon

enough to have 1 or 2 threads showing on the top of the bolt. Place the wedge end of the bolt into

one of the holes, going through the outside tension bracket, metal Vector pad and into the concrete.

10. Usingahammer,tapthewedgeboltintothehole.Maximumheightforexpansionboltabove

 concreteis2”.

11. RepeatfortheotherholeintheoutsidetensionbracketandthetwoholesontheotherVector

system pier set.

12. Place an inside tie bracket over the u-bolt so that the lip of the bracket is between the Vector plate

 andconcreteblocks.PlacewashersandnutsoneachU-bolt.Donottightenyet(seeillustrationTwo).

13. Attachahookorswivelstraptotheinsidetiebracket,withsufficientlengthtogooverthe

opposite pier and down to the outside tension bracket, plus 12 inches for wrapping the slotted

bolt. (If using hook, place hook underneath the inside tie bracket, flat against compression board)

 Repeatfortheoppositeside.

14. Tighten inside u-bolts at this time.

15. Usetheoutsidetensionbracketstoremoveanyspacebetweentheoutsidetensionbrackets,

concrete blocks and the inside edge of the Vector pad, by tapping the brackets with a hammer.

Wedge the pier set at this time.

16. Usinga9/16”socketwrench,tightenallofthewedge/anchorbolts,securingtheoutsidetension

bracket and Vector pad to the concrete.

17. Usingaslottedboltintheoutsidetensionbrackets,insertstrapthroughslottedboltwithendof

strap aligned with outside edge of bolt. Turn slotted bolt until straps are tight using at least five

turns on the slotted bolts.

Vector Dynamics System

for Concrete Applications

Instructions

Vector pad

for

concrete

Compression

boards or

PVC Pipe

Concrete

footer

Inside

Tie Bracket

U-bolt

Illustration Two

Inside of home

1 2 ... 12 13 14 15 16 17 18 19

Keine Kommentare

Tie-down Vector Dynamics Foundation System for Wind Zones I Bedienungsanleitung Seite 17